How do you reset OBC on a club car?
4 min read
Asked by: Amy Hansen
Easily Reset the Club Car Golf Cart OBC
- Key switch to off.
- Set forward/reverse to neutral.
- Put tow/run switch to tow.
- Disconnect the negative battery terminal from the battery pack.
- Put the tow/run switch to run.
- Put forward/reverse switch to reverse.
- Put key switch to on.
How do you reset the onboard computer on a Club Car Precedent?
How to reset your Club Car’s OBC after a fault
- Key Switch to Off.
- Forward/Reverse to Neutral.
- Tow/Run Switch to Tow.
- Disconnect the Battery NEGATIVE (–) wire from the Battery Minus terminal on the battery pack.
- Put the Tow/Run to Run.
- Forward/Reverse Switch to Reverse.
- Key Switch to On.
- Lock the throttle pedal down.
Where is the reset button on a Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
How do you bypass OBC on Club Car DS?
To bypass the OBC you will need to connect a 12 gauge black wire from the negative terminal of this battery to where the black wire attaches to the back of the receptacle. That’s it folks; you’re done!
Does a club car have a reset button?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.
What is OBC on golf cart?
Club Car uses an On Board Computer (or OBC) to monitor and control various functions of their carts. It functions as a Go/No Go control for the charging and drive systems. If the OBC detects a problem in either the charging or drive system, it will shut that feature off.
How do I test my OBC golf cart?
How to Test Club Car Precedent Controller?
- Connect a voltmeter to the negative terminal on the battery.
- Connect the voltmeter to the M terminal on the controller.
- Push down on the golf cart pedal.
- A clicking sound should be heard.
- The batteries show a full charge.
Where is the OBC on a Club Car golf cart?
Yes okay back up here's a battery compartment. And see they put the electronics in the back behind that metal plate and that's the OBC you see straight down that's it right there that's the top of it.
Where is the reset button on an electric golf cart motor?
First, you’ll want to reset your motor.
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you’re in luck!
What does the OBC do on a Club Car DS?
The OBC is a small device that is wired into the golf cart that’s purpose is to regulate the batteries charge. As you use and drive your golf cart, the OBC records the amount of energy consumed and then directs the charger to replace exactly the amount of energy needed to fully replenish the batteries.
How do I know if my club car controller is bad?
X Common Symptoms of Controller Failure
- Top Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. …
- Sudden and Unexpected Slowing. …
- Shuttering or Shaky Driving. …
- Stalling Out and Refusing to Start. …
- Surges in Speed When Driving.
How do you troubleshoot an electric club car?
Make sure your key switch is on step on the accelerator. You should get a light here.
How do you reset a golf cart battery meter?
Battery Meter Always Shows Full
Reset the battery meter. Unhook power to the battery meter for 10 minutes. This will reset the battery meter.
How do I reset my club car computer?
Easily Reset the Club Car Golf Cart OBC
- Key switch to off.
- Set forward/reverse to neutral.
- Put tow/run switch to tow.
- Disconnect the negative battery terminal from the battery pack.
- Put the tow/run switch to run.
- Put forward/reverse switch to reverse.
- Put key switch to on.
What would cause a golf cart not to charge?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
